全自動釀酒設備廠家為您簡單介紹新的釀酒設備在運用前要做哪些作業：跟著釀酒工藝技術的廣泛傳播，許多人在創業時將方針放在了釀酒設備上，但是關于酒液來說。
Fully automatic brewing equipment manufacturers give you a brief introduction of what the new brewing equipment should do before it is used: with the wide spread of brewing technology, many people put the policy on brewing equipment when they start their business, but for liquor.
它屬于食物范圍內，與人的身體健康有直接關系，因此，在釀造之前需要對釀酒設備進行完全，使細菌控制在必定范圍內，讓生產出的酒液衛生口感更好?，F(xiàn)在就一起來了解下新的釀酒設備在運用前要做哪些作業吧。
It belongs to the food range and has a direct relationship with human health. Therefore, before brewing, it is necessary to completely disinfect the brewing equipment, so that bacteria can be controlled in a certain range, so that the produced liquor has a better hygienic taste. Now let's get to know what the new brewing equipment should do before it is put into use.
1.釀酒設備在裝置前行：釀酒設備在裝置前必定要用清水對設備進行完全的清洗，確保釀酒進程的根底性。
1. The brewing equipment should be disinfected before the installation: before the installation, the brewing equipment must be completely cleaned and disinfected with clean water to ensure the safety of the brewing process.
2.釀酒設備運用前需要用蒸汽進行再次：裝置前的一次遠遠不夠，我們在運用設備之前還需要做一次作業，這次是用蒸汽進行，具體方法是：往鍋爐里加水高水位線，燒火。鍋爐、酒料桶、冷卻器之間用導汽管連接，待水燒開后大約半小時以后，熄火，蒸汽作業完成。
2. The brewing equipment needs to be sterilized again by steam before it is used: the first disinfection before the equipment is far from enough, and we need to do a disinfection operation before using the equipment. This time, we use steam to sterilize and disinfect. The specific method is to add water to the boiler to the highest water level and burn fire. Boilers, barrels and coolers are connected by steam pipes. After about half an hour of boiling water, the fire is extinguished and the steam disinfection operation is completed.
3.蒸酒進程中隨時觀察蒸汽柜水位：蒸酒之前應當將蒸汽柜內的水加高水位線，并在蒸餾的進程中隨時檢查水位管中的水是否低于低水位線，假如發現水位快要挨近低水位時應當減小火力，及時向爐中加水。
3. Watch the water level of the steam cabinet at any time during the process of steaming: before steaming, the water in the steam cabinet should be added to the highest water level, and check whether the water in the water level pipe is below the lowest water level at any time during the process of distillation. If it is found that the water level is near the lowest water level, the firepower should be reduced and water should be added to the furnace in time.
4.蒸汽柜防止無水空燒：有的時分大意了，蒸汽柜的水分現已被燒完，這個時分會呈現無水空燒的狀況，這樣不僅對設備是極大地損耗，而且或許引發火災。所以，大家必定要注意這一點。
4. Steam cabinet to prevent anhydrous air burning: Sometimes carelessly, the water of the steam cabinet has been burned out, which will present the situation of anhydrous air burning, which is not only a great loss of equipment, but also may cause fire. Therefore, we must pay attention to this point.
5.蒸酒之后必須要進行排水排糟清洗設備：要養成一個良好的習氣：每次蒸完酒之后必定要進行排水排糟，并對釀酒設備進行及時的清洗，以免形成設備阻塞。
5. After steaming, the drainage and drainage equipment must be cleaned: a good habit should be formed: every time after steaming, the drainage and drainage equipment must be cleaned in time to avoid blocking the equipment.
不利于下一次運用。釀酒設備的生產進程與酒液的食物密切相關，因此滅毒作業是十分重要的，另外就是這種操作也會讓群眾在喝的時分更安心、更放心。
Not conducive to the next use. The production process of liquor-making equipment is closely related to the food safety of liquor, so sterilization and disinfection is very important. In addition, this operation will also make people feel more at ease and at ease when drinking.
Above information is our vending machine to organize and publish the hope to help you all on our website is: http://m.tersatig.cn/!
自動售酒機 2024-07-25 
