不銹鋼內膽實木酒桶因?yàn)椴馁|(zhì)是不銹鋼做的，所以比普通的存儲罐更具有較強的耐腐性和密封性，能夠有效阻止污物進入罐體，不銹鋼有一個非常顯著的優點就是不需要經常清洗。廣泛應用于酒業、藥業、乳制品、調味品、飲料、化工等領域，像酒廠這樣的地方使用不銹鋼內膽實木酒桶比較多，因此，
不銹鋼內膽實木酒桶防護尤為重要。
Because the stainless steel solid wood wine barrel is made of stainless steel, it has stronger corrosion resistance and sealing performance than ordinary storage tanks, and can effectively prevent dirt from entering the tank. Stainless steel has a very significant advantage that it does not need to be cleaned frequently. It is widely used in the wine industry, pharmaceutical industry, dairy products, condiments, beverages, chemicals and other fields. In places like distilleries, more solid wood wine barrels with stainless steel liners are used. Therefore, the safety protection of solid wood wine barrels with stainless steel liners is particularly important.
在使用不銹鋼內膽實木酒桶的過程中，除了要做好密封儲存的物質避免受到外界物質污染外，還需要讓里面密封的物質不會出現高溫或炭化，這就需要我們做好保溫措施。尤其是在冬天，對不銹鋼內膽實木酒桶也是要防寒保溫的，避免傷害罐內的管道，損害機械設備。
In the process of using the solid wood wine barrel with stainless steel liner, in addition to doing a good job in sealing the stored substances to avoid being polluted by external substances, we also need to ensure that the sealed substances inside will not be high-temperature or carbonized, which requires us to do a good job in thermal insulation measures. Especially in winter, the solid wood wine barrel with stainless steel liner should also be protected from cold and heat to avoid hurting the pipes in the tank and damaging mechanical equipment.
新買的不銹鋼內膽實木酒桶里，廠家一般都隨桶中贈送一袋食用堿，聲稱用食用堿或小蘇打，加溫水泡幾個小時，即把桶壁清洗干凈。照此辦理，并用一條舊毛巾反復擦洗桶內壁3次，再用干凈的水沖洗3次，測試結果如下：
In the newly bought stainless steel liner solid wood wine barrel, the manufacturer usually presents a bag of edible soda with the barrel, claiming to use edible soda or baking soda to warm the water for a few hours, that is, to clean the barrel wall. Follow this procedure, and repeatedly scrub the inner wall of the barrel with an old towel for three times, and then rinse it with clean water for three times. The test results are as follows:
①桶的直壁、桶底都是潔凈的。用紙巾擦拭這兩個部位，紙巾都是潔白的，無任何污點。
① The straight wall and bottom of the barrel are clean. Wipe these two parts with a paper towel. The paper towel is white and free of any stains.
②但是當擦拭桶的直壁與縮口交界部位，即環形的條帶，寬度約1CM，潔白的紙巾上面就有了大塊的黑色油污痕跡。仔細觀察這個桶壁區域，沒看到明顯的污跡啊，用手指肚擦一下，指肚上面干干凈凈的，看不出污跡。再用紙巾擦一擦，新的紙巾又變黑了。把桶搬到陽臺處，再仔細觀察這個條帶，原來這個環帶上布滿了淺淺的豎痕，這是生產加工過程中留下來的痕跡，當時沒有打磨平整，豎痕中積藏了一些油膩。
② However, when wiping the junction of the straight wall of the barrel and the necking, that is, the annular strip with a width of about 1cm, there are large black oil stains on the white paper towel. Carefully observe the barrel wall area, and you can't see any obvious stains. Wipe it with your finger. The upper part of your finger is clean, and you can't see any stains. Wipe with a paper towel again, and the new paper towel turns black again. Move the bucket to the balcony and carefully observe the belt. It turns out that the belt is full of shallow vertical marks, which are left over from the production process. At that time, it was not polished flat, and some greasiness was accumulated in the vertical marks.
此外在安裝不銹鋼內膽實木酒桶是要先檢查一下罐內有沒有雜志，仔細清洗罐內外，清洗完成后，查看罐內有沒有積水，須要保持罐體干燥，將保溫層固定在儲罐，并排列整齊，不銹鋼內膽實木酒桶的維護和保養，應交由相關的人員來維護，維護人員應嚴格遵守規章制度，以防止出現危險，確保自身的。
In addition, before installing the stainless steel liner solid wood wine barrel, it is necessary to first check whether there are magazines in the tank, carefully clean the inside and outside of the tank. After cleaning, check whether there is water in the tank. It is necessary to keep the tank dry, fix the insulation layer on the tank and arrange it in order. The maintenance and repair of the stainless steel liner solid wood wine barrel should be entrusted to relevant professionals. The maintenance personnel should strictly abide by rules and regulations to prevent dangers, Ensure your own safety.
不銹鋼內膽實木酒桶的使用及維護部分內容就是這樣了，希望看完能夠給您好的幫助，更多相關內容就來我們網站
http://m.tersatig.cn咨詢了解吧！
This is the use and maintenance of the stainless steel liner solid wood wine barrel. I hope I can help you after reading it. Please come to our website for more relevant content http://m.tersatig.cn Consult and understand!
自動售酒機 2024-07-25 
